INSTALLATION AND INSTRUCTION MANUAL
FREEZER
UF406W
UF406GR
ECF406W
IMPORTANT SAFETY INSTRUCTIONS
These warnings are provided in the interests of your safety. Ensure that you understand them
all before installing or using this appliance. Your safety is of paramount importance. If you are
unsure about any of the meanings or these warnings contact the Customer Care Department.
Installation
Maintenance and Cleaning
This appliance is heavy. Care should be taken
when moving it.
Switch off, and unplug the appliance before
carrying out any cleaning or maintenance
work.
Do not use sharp instruments to scrape off frost or
ice. (See defrosting instructions).
It is dangerous to alter the specifications or
attempt to modify this product in any way.
Ensure that the appliance does not stand on
the electrical supply cable. If the supply cord is
damaged, it must be replaced by a special
cord available from your local Service Force
Centre.
Any electrical work required to install this
appliance should be carried out by a qualified
electrician or competent person.
Parts which heat up should not be exposed.
Whenever possible, the back of the appliance
should be close to a wall but leaving the
required distance for ventilation as stated in
the installation instructions.
Servicing
This product should be serviced by an
authorised engineer, and only genuine spare
parts should be used.
Under no circumstances should you attempt to
repair the machine yourself. Repairs carried
out by inexperienced persons may cause injury
or serious malfunctioning. Contact your local
Service Force Centre.
The appliance should be left for 2 hours after
installation before it is turned on, in order to
allow the refrigerant to settle.
At the End of the Appliance Life
When disposing of your appliance, use an
authorised disposal site.
Remove the plug and ensure that any locks or
catches are removed, to prevent young
children being trapped inside.
Child Safety
Do not allow children to tamper with the
controls or play with the product.
During Use
This appliance is designed for domestic use
only, specifically for the storage of edible
foodstuffs only.
Frozen food should not be refrozen once it has
thawed out.
Please read this
instruction book carefully
before use and retain
for future reference.
Do not place carbonated or fizzy drinks in the
freezer.
Ice lollies can cause 'frost/freezer burns' if
consumed straight from the freezer.
Do not remove items from the freezer if your
hands are damp/wet, as this could cause skin
abrasions or frost/freezer burns.
Manufacturers' recommended storage times
should be adhered to. Refer to relevant
instructions.
3
TABLE OF CONTENTS
For the User
For the Installer
Installation Instructions
15
Important Safety Instructions
Description of the Appliance
Control Panel
3
5
5
Technical Information
15
Electrical Connections
Electrical Requirements
16
16
Installation Requirements
Ventilation Requirements
Levelling
17
17
17
Using Your Appliance
Before Use
To Start The Appliance
Thermostat Controls
6
6
6
6
Door Reversal
18
Indicator Lights
7
Side Fixed Handle Change 19
Guarantee Conditions 20
Fast Freeze Facility
The Freezer Compartment
Freezing Fresh Food
7
8
8
8
Frozen Food Storage
Hints and Tips
9
9
9
9
9
Normal Operating Sounds
Food Storage
Energy Saving Advice
In the Event of a Power Failure
Maintenance and Cleaning
Internal Cleaning
External Cleaning
To Defrost the Freezer
When the Appliance is Not in Use
10
10
10
10
10
What Happens if Something
Goes Wrong
11
12
13
Service and Spare Parts
Service Centres
4
Description of the Appliance
Heat Resistant Top
Control Housing
Freezer Calendar
Freezing/Storage Shelf
Storage Baskets
Defrost Spout
Level Adjusters
Control Panel
FASTFREEZE
THERMOSTAT
INDICATOR LIGHTS
5
USING THE APPLIANCE
This appliance is designed for
domestic use only, specifically for the
storage of edible foodstuffs.
This appliance is designed to operate in
ambient temperatures (surrounding air
temperature) between 10°C (50°F) and 32°C
(90°F).
If these temperatures are exceeded i.e.,
colder or warmer, the appliance will not
operate correctly. Should the ambient
temperatures be exceeded for long periods,
the temperature in the freezer section will rise
above -18°C and food spoilage may occur.
Before Use
Remove all securing tapes.
Wash the inside of the appliance with lukewarm
water with a little bicarbonate of soda added (5ml
to 0.5 litre of water). Do not use soap or
detergent as the smell may linger. Dry the
appliance thoroughly.
Do not use detergents, abrasive
powders, highly perfumed cleaning
products, wax polishes or products
containing alcohol.
To Start the Appliance
1. Allow the appliance to stand for 2 hours
after installation.
2. Plug in the appliance and switch on at the
mains supply.
3. Turn the thermostat control to the required
setting. A midway setting is usually suitable
for normal operation (see thermostat control).
4. Leave the appliance for approximately 4
hours for the correct temperature to be
reached before placing food inside.
Thermostat Control
The thermostat control situated in the control
panel regulates the temperature of the freezer
compartment. Thermostat control is marked from
1-6, the higher the number, the colder the setting.
Position 1 - Cold
Position 6 - Coldest
The temperature will be affected by:
Room temperature
How often the door is opened
How much food is stored
Position of the appliance
In determining the correct temperature control
setting, all these factors have to be considered
and some experimentation may be necessary.
Do not allow children to tamper with the
controls or play with the product.
6
INDICATOR LIGHTS
The Indicator Lights are situated in the control
panel.
AMBER INDICATOR
GREEN INDICATOR
Green Indicator Light
When the appliance is switched on at the mains
the green indicator light will glow and continue to
glow until the appliance is switched off at the
mains.
Red Indicator Light
A few hours after starting up this will go out to
show that the correct temperature has been
reached for the setting chosen and will stay out
to indicate that everything is in order.
RED INDICATOR
It will come on if the freezer temperature rises
unduly for instance, after opening the freezer
door or placing food inside the cabinet, but the
light should go out again when the temperature
returns to normal.
Amber Indicator Light - (Fast Freeze)
With the fast freeze on the Amber Indicator light
will come on and stay on as a reminder.
FAST FREEZE FACILITY
The fast freeze switch overrides the thermostat
and should be used when freezing fresh foods.
It is operated by switching the switch from the
normal position '0' to 'I'.
7
The Freezer Compartment
Frozen Food Storage
The appliance has the following net storage
volume:
The
symbol means that your freezer will
store frozen food at -18°C (-0.4°F) or colder
allowing for long term frozen food storage and
freezing of fresh food. The freezer temperature is
controlled automatically by the thermostat
situated in the control panel.
82 litres (2.89 cuft)
26.2 kg (57.8 lb)†
† This is a standard measurement and the
actual capacity depends upon the density
and sizes of the food. The above figures are
based on an average density of 0.32kg per
litre (20 lb per cuft).
Due to the different installations, methods of
usage and weather conditions, adjustments to the
temperature settings may be required.
These are best assessed against a
temperature reading on a thermometer
buried in the frozen food. The reading
must be taken quickly as the thermometer
temperature will rise rapidly after removal.
Pre packed commercially frozen food should be
stored in accordance with the manufacturer's
instructions for a 4 star frozen food compartment
and should be put in the freezer as soon as
possible after purchase. Your freezer provides for
long term storage which generally means up to 3
months but the length of the time can vary and it
is important to follow the recommended times
shown on packets of commercially frozen food.
Freezing Fresh Food
The maximum quantity of food you can freeze in
24 hours is 8kg. Place the fresh food on the top
freezer shelf. Food may need rearranging to
achieve this.
During the freezing process the temperature of
fresh food should be reduced quickly so that ice
crystals are kept as small as possible to prevent
damaging the structure of food. If freezing takes
place slowly large ice crystals form and these will
affect the quality of food once it has defrosted.
Switch the fast freeze switch to 'I' (ON) 24 hours
before loading the food. 24 hours after loading
the food return the switch to '0' (OFF). Existing
frozen foods should be re-arranged to leave
space on the top two shelves for freezing. The
packets to be frozen should be placed on the
shelf in contact with the shelf surface as far as
possible and spaced apart to allow cold air to
circulate between them. They should not touch
existing packets.
If there is room, transfer the food you have frozen
to the baskets or drawer to allow you to freeze a
further load on the top shelf. No harm will result if
you forget to turn off the fast freeze switch after
24 hours, but for reasons of economy, try to
remember to turn it off when freezing is complete.
The amber light should remind you of this.
Exceptionally large items can be stored by
removing the upper basket.
Do not place sealed containers or
carbonated liquids such as fizzy drinks
into the freezer as it creates pressure
on the container which may cause it to
explode resulting to damage to the
freezer.
Ice cubes and ice lollies should not be
consumed immediately after removal
from the freezer as it may result in low
temperature skin abrasions.
Manufacturers storage times should be
adhered to.
Hints and Tips
Any opened packets of frozen food,
should be rewrapped in airtight materials
to prevent surface evaporation which
causes drying or 'freezer burn'.
Frozen food which is allowed to thaw
accidentally should either be used
immediately or thrown away. Alternatively
if the food is uncooked and has not been
completely defrosted it can be cooked and
then refrozen.
Aim to check dates on packets and rotate
food regularly. Although storage longer
than recommended is not harmful, flavours
and textures begin to change.
Frozen food should not be refrozen
once it has thawed out.
Do not remove items from the freezer if
your hands are damp/wet, as this could
cause skin abrasions or 'frost/freezer
burns'.
For safety reasons, the freezer baskets are fitted
with stops but are readily removed by pulling
them forward to the stop, then lifting the front and
pulling all the way out. Re-fit by reversing this
procedure.
8
HINTS AND TIPS
Normal Operating Sounds
Always leave warm food to cool down to room
temperature before placing in the fridge or
freezer.
You may hear faint gurgling or bubbling
sounds when the refrigerant is pumped
through the coils or tubing at the rear, to the
cooling plate/evaporator or to the fixed
freezer shelves.
Food which is to be frozen (when cool) should
be placed in the fridge before being
transferred to the freezer.
When the compressor is on, the refrigerant is
being pumped round, and you will hear a
whirring sound or pulsating noise from the
compressor.
Thaw frozen food in the fridge. This will
ensure safer defrosting of foods and reduce
the work of the refrigeration unit.
A thermostat controls the compressor, and
you will hear a faint 'click' when the
thermostat cuts in and out.
Try to avoid keeping the door open for long
periods, or opening the door too frequently as
warm air will enter the cabinet, and cause the
compressor to switch on unnecessarily often.
Food Storage
Ensure there are no obstructions preventing
the door from closing properly.
To obtain the best results from your appliance,
neither hot foods nor liquids which may
evaporate, should be placed in the larder
compartment.
It is advisable to periodically clean the
refrigeration system at the back of the
appliance with a duster or vacuum cleaner.
Avoid buying frozen food if you cannot store it
straight away. The use of an insulated
container is advisable. When you arrive home
place the frozen food in the freezer
immediately.
In the Event of a Power Failure
If there is a power failure during the storage of
frozen foods, keep the door closed. If the
temperature within your freezer should rise do not
refreeze the food without checking it's condition.
The following guidelines should assist you:
Keep the time between buying chilled food
and placing it in your fridge as short as
possible.
Ice Cream: Once thawed should be discarded.
Do not push food together too much, try to
allow air to circulate around each item.
Fruit and Vegetables: If soft should be cooked
and used up.
Do not store food uncovered.
Bread and Cakes: Can be refrozen without
danger.
Ensure that food placed in the freezer is
dated and labelled and used in date order to
ensure that food is consumed at its best.
Shellfish: Should be refrigerated and used up
quickly.
Remove suspect food from your refrigerator
and clean, refer to cleaning and maintenance.
Cooked Dishes: i.e. casseroles, should be
refrigerated and used up.
Energy Saving Advice
Do not install the appliance close to sources
of heat, such as a cooker, dishwasher or
radiator.
Large Pieces of Meat: Can be re-frozen
providing there are ice crystals remaining within
them.
Small Joints: Should be cooked and then
re-frozen as cooked dishes.
Locate the appliance in a cool well ventilated
room and make sure that the air openings of
the cabinet are not obstructed.
Chicken: Should be cooked and re-frozen as a
fresh dish.
Avoid unnecessary frosting in the cabinet by
packing all foodstuffs into airtight packages
before placing them in the freezer.
9
MAINTENANCE AND CLEANING
Before any maintenance or cleaning work
is carried out DISCONNECT the appliance
from the ELECTRICITY supply.
Internal Cleaning
Clean the inside and accessories with warm water
and bicarbonate of soda (5ml to 0.5 litre of water).
Rinse and dry thoroughly.
Do not use detergents, abrasive powders,
highly perfumed cleaning products, wax
polishes or cleaning products containing
bleach or alcohol.
External Cleaning
Wash the outer cabinet with warm soapy water.
Do NOT use abrasive products.
There are sharp edges on the underside
of the product so care should be taken
when cleaning.
Once or twice a year dust the condenser (black
grille) and the compressor at the back of the
appliance, with a brush or vacuum cleaner, as an
accumulation of dust will affect the performance
of the appliance and cause excessive electricity
consumption.
To Defrost the Freezer
1.
2.
Wrap any food in layers of newspaper or
blankets.
Switch the appliance off at the wall socket
and remove the plug.
3.
4.
5.
Open the freezer door.
Fold out the defrost flip spout.
Place a suitable container under the spout
to collect the defrost water.
6.
7.
After defrosting, clean and dry the interior.
Switch the appliance on and replace any
frozen food.
Defrosting can be speeded up by putting
bowls of hot (not boiling) water in the
freezer and loosening the frost with a
suitable plastic scraper.
If the temperature of frozen food is
allowed to rise during defrosting, its
storage life may be shortened.
When the Appliance is Not in Use
When the appliance is not in use for long periods,
disconnect from the electricity supply, empty all of
the food and clean the appliance, leaving the
door ajar to prevent unpleasant smells.
10
WHAT HAPPENS IF SOMETHING GOES WRONG
BEFORE contacting your local service force centre, check the following points:
Symptom
Solution
No power to the appliance
Check there is power at the socket.
Check there is not a power cut by checking the
household lights.
Check the fuse has not blown.
The temperature in the freezer section is too high Check the thermostat is turned to the correct
setting relative to ambient conditions.
Check the ambient temperature is within the
appliances operating limits of 10°C to 32°C.
Relocate the appliance if necessary.
The freezer door will not open
- Has door just been opened?
If so leave for a few minutes to allow the air
pressure to equalise.
The compressor runs continuously
Adjust the thermostat to give correct temperature
control. See page 6.
Check that the door is closed.
Large quantities of food have recently been
placed in the cabinet / and or door is frequently
opened.
Check that air ventilation is not obstructed.
Ensure the door is not left open.
Excessive frost and ice has built up
Check that nothing is preventing the door from
closing.
Is the door gasket intact and clean.
Has advised periodic defrosting been carried out.
Refer to normal operating sounds.
Noise
If after the above checks there is still a fault call your local Service Force Centre.
In-guarantee customers should ensure that the above checks have been made as the engineer will
make a charge if the fault is not a mechanical or electrical breakdown.
Please note that proof of purchase is required for in-guarantee service calls.
11
Service and Spare Parts
If you require service or spare parts please
contact your local Service Force Centre by
telephoning:
0990 929929
The address of your local centre can be found on
the following pages; and also in your local
telephone directory.
Before contacting your local Service Force Centre
make a note of the model and serial number,
together with the date of purchase. The service
department will require this information.
The model and serial number can be found on the
rating plate situated inside the cabinet.
12
TRICITY BENDIX SERVICE FORCE
To contact your local Tricity Bendix Service Centre telephone 0990 929929
CHANNEL ISLANDS
SCOTLAND
NORTHERN IRELAND
WALES
NORTH WEST
NORTH EAST
13
TRICITY BENDIX SERVICE FORCE
To contact your local Tricity Bendix Service Centre telephone 0990 929929
LONDON & EAST ANGLIA
MIDLANDS
SOUTH WEST
Unit 7 Oaks Industrial
Estate
Coventry Road
Narborough
Leicestershire
LE9 5GF
WEST DRAYTON
(M76)
2 / 4 Royal Lane
Yiewsley
West Drayton
Middlesex
UB7 8DL
SOUTH EAST
14
INSTALLATION INSTRUCTIONS
Technical Information
(UF406W)
(UF406GR)
DIMENSIONS
HEIGHT:
DIMENSIONS
HEIGHT:
85.0 cm (33.4")
49.5 cm (19.5")
60.0 cm (23.6")
85.0 cm (33.4")
49.5 cm (19.5")
61.5cm (24.2")
WIDTH:
WIDTH:
DEPTH:
DEPTH:
CAPACITY
GROSS:
97.0 litres
82.0 litres
NET:
STAR RATING:
POWER ABSORBED:
VOLTAGE:
100W
230 - 240V
50Hz
FREQUENCY:
AVERAGE DAILY UNITS OF ELECTRICITY:
1.1Kwh *
*
THIS FIGURE IS BASED ON STANDARD TEST RESULTS IN THE EUROPEAN STANDARD
EN153. ACTUAL CONSUMPTION WILL DEPEND ON HOW THE APPLIANCE IS USED AND
WHERE IT IS LOCATED.
subsequent
modifications.
It is dangerous to alter the specifications or
attempt to modify this product in any way.
15
Electrical Connections
Any electrical work required to install this
appliance should be carried out by a
qualified electrician or competent person.
This appliance must be earthed.
The manufacturer declines any liability should
these safety measures not be observed.
Electrical Requirements
Before switching on, make sure the electricity
supply voltage is the same as that indicated on
the appliance rating plate.
The appliance is supplied with a 13 amp plug
fitted. In the event of having to change the fuse in
the plug supplied, a 13 amp ASTA approved
(BS1362) fuse must be used.
Should the plug need to be replaced for any
reason. The wires in the mains lead are coloured
in accordance with the following code:
Green and Yellow
Blue
Brown
: Earth
: Neutral
: Live
The wire coloured green and yellow must be
connected to the terminal marked with the letter
"E" or by the earth symbol
and yellow.
or coloured green
The wire coloured blue must be connected to the
terminal marked "N" or coloured black.
The wire coloured brown must be connected to
the terminal marked "L" or coloured red.
Upon completion there must be no cut, or stray
strands of wire present and the cord clamp must
be secure over the outer sheath.
16
Installation Requirements
To ensure correct operation this appliance
must not be located where the temperatur
will fall below 10°C (50°F) or rise above 3
(90°F).
OR
Avoid the following locations: unheated
kitchen, outhouse, conservatory, garage.
For correct operation this appliance must be
installed:
In a dry atmosphere.
Out of direct sunlight.
Away from extreme temperature (not next to a
cooker or other sources of heat).
Your appliance will be heavy when loaded
with food and must therefore be stood on a
strong firm floor.
Ventilation Requirements
WALL
Gently push into place until the top panel rear
ventilation grille touches against the wall.
When in position a 50 mm (2") clear space
above the appliance should be maintained.
If space above the appliance is not available,
clearance of 25mm (1") should be maintained
on both sides.
Ensure that the appliance does not stand
on the electrical supply cable.
Parts which heat up should not be
exposed. Whenever possible , the back of
the appliance should be close to a wall but
leaving the required distance for
ventilation.
Levelling
The appliance should be level, to eliminate
rocking:
Ensure the appliance is upright and both
adjusters are in firm contact with the floor so
that the cabinet is level.
Adjust the level by screwing out the
appropriate level adjuster at the front, (use
your fingers or a suitable spanner).
This appliance is heavy. Care should be
taken when moving it.
17
Door Reversal
1. Disconnect the appliance from the electricity
supply.
2. Remove all loose items, including food. Store
food in a cool place.
3. Make sure a towel or cloth is at the base of
the product to prevent it from slipping.
4. Carefully lean the appliance backwards,
resting the top on a stool, or something
similar, at least 30cm (12") from the floor.
(care must be taken not to allow the appliance
wheels to slip).
Do not support the appliance on the rear
ventilation grille or condenser.
5. Remove level adjuster (A) from base of
product retaining small cup spacer which is
located around the threaded portion of the
adjuster.
6. Remove the foot / hinge assembly (B) by
removing screws marked (C).
7. Remove the door by lifting it slightly and
carefully sliding it down off the top hinge pin
(F) by removing screw (G) and transfer to the
opposite side.
8. Refit the door by carefully sliding it onto the
upper hinge pin (F). Take the bottom hinge
foot assembly (B) and transfer it over to the
opposite side of the cabinet being careful to
retain any spacing washer fitted onto the
bottom hinge pin. Push the hinge foot
assembly (B) into the door bearing using the
pin of the foot for location. Three holes will
then line up with the hinge foot and screws (C)
should be used to secure the hinge.
9. Refit level adjuster in the opposite side of the
cabinet.
B
A
The base of your product should now be in
line with the diagram.
10. Stand the appliance upright.
C
18
Side Fixed Handle Change
i) Protect the paintwork from damage with
masking tape or other suitable material while
using a blunt knife or similar instrument to
carefully prise out the plastic plugs from
alternative handle positions on the opposite side
of the door.
ii) Remove the screw covers and screws from the
handle and transfer it to its new position replacing
the screw covers, then replace the plastic plugs
into the vacated screws holes.
19
GUARANTEE CONDITIONS
Standard guarantee conditions
We, Tricity Bendix, undertake that if within 12 months of the date of the purchase this Tricity Bendix appliance or
any part thereof is proved to be defective by reason only of faulty workmanship or materials, we will, at our option
repair or replace the same FREE OF CHARGE for labour, materials or carriage on condition that:
The appliance has been correctly installed and used only on the electricity supply stated on the rating
plate.
The appliance has been used for normal domestic purposes only, and in accordance with the
manufacturer's instructions.
The appliance has not been serviced, maintained, repaired, taken apart or tampered with by any person
not authorised by us.
All service work under this guarantee must be undertaken by a Tricity Bendix service centre.
Any appliance or defective part replaced shall become the Company's property.
This guarantee is in addition to your statutory and other legal rights.
Home visits are made between 8.30am and 5.30pm Monday to Friday. Visits may be available outside
these hours in which case a premium will be charged.
Exclusions
This guarantee does not cover:
Damage or calls resulting from transportation, improper use or neglect, the replacement of any light bulbs
or removable parts of glass or plastic.
Costs incurred for calls to put right an appliance which is improperly installed or calls to appliances outside
the United Kingdom.
Appliances found to be in use within a commercial environment, plus those which are subject to rental
agreements.
Products of Tricity Bendix manufacture which are not marketed by Ticity Bendix.
European Guarantee
If you should move to another country within Europe then your guarantee moves with you to your new home subject
to the following qualifications:
The guarantee starts from the date you first purchased your product.
The guarantee is for the same period and to the same extent for labour and parts as exists in the new
country of use for this brand or range of products.
This guarantee relates to you and cannot be transferred to another user.
Your new home is within the European Community (EC) or European Free Trade Area.
The product is installed and used in accordance with our instructions and is only used domestically, i.e. a
normal household.
The product is installed taking into account regulations in your new country.
Before you move please contact your nearest Customer Care centre, listed below, to give them details of your new
home. They will then ensure that the local Service Organisation is aware of your move and able to look after you
and your appliances.
France
Senlis
+33 (0)3 44 62 28 28
+49 (0)911 323 260
+39 (0)1678 47053
+46 (0)20 78 77 50
+44 (0)1635 525 542
Germany Nürnberg
Italy
Pordenone
Stockholm
Newbury
Sweden
UK
20
FREEZER UF406W/GR ECF406W 822020595-00
9/1997
822020595-00
|